From: Stu (stuinnh@mvnut.us)
Date: Fri Jul 22 2005 - 15:37:24 PDT
Check the started to make sure the bolts are tight and the front mounting
bracket bolt is in place.
"Stu"
Southern NH, USA
"Live Free Or Die"
MVPA #14790
1967 M151A1 Jeep 1964 M416 Trailer
1985 M1008 CUCV Pickup
-----Original Message-----
From: Military Vehicles Mailing List [mailto:mil-veh@mil-veh.org] On Behalf
Of Tom Kelly
Sent: Friday, July 22, 2005 6:24 PM
To: Military Vehicles Mailing List
Subject: [MV] CUCV Saga.....ALMOST Over
I went out this morning with the intent to install an electric fuel pump
near the tank to pressurize my fuel lines and see if I had any leaks
that could have been sucking air. Imagine my surprise/dismay as I got
splashed with gasoline! Probably not a good thing, the CUCV being a
DIESEL and all.....What in the world!! I have no idea how it got gas in
it.
I hooked up the electric pump and drained over 4 gal. of gas out of her.
I put in 2 gal of diesel, and drained almost 1 gal out until I was happy
that it WAS diesel. I got 2 Jerrycans worth of diesel and poured them
in. I finished installing the electric fuel pump, drained the fuel
filter, and purged it of gasoline, and got it back together. I then
removed all the glow plugs, cracked open the injector lines, and turned
her over about 5-6 times at 15 seconds per time, until I was sure I had
diesel and not gas at the injectors. I then tightened up all the lines,
turned her over 3 more times for 15 seconds, re-installed the glow plugs
and cranked her over, she STARTED!!!!!! Woo -Hoo!!!
I let her run for about 15 minutes, then shut her down so I could remove
the jury-rigged electric fuel pump since it wasn't needed. When I tried
to restart her the starter just makes a whiny noise but doesn't turn the
engine....What in the world! It had been threatening me for a while I
guess she finally died. I'll probably pull it and take it to Gen-Star to
see if they can rebuild it, because I think new ones are in the $250.00
price range (OUCH!!) If anyone knows of good prices on a starter feel
free to contact me off list.
Anyway, except for the starter I think the CUCV lives again, and
hopefully my problems are over, and now I know about CUCV's (more than I
ever wanted to know).
Thanks for all your help through this ordeal - Tom
===Mil-Veh is a member-supported mailing list===
To unsubscribe, send e-mail to: <mil-veh-off@mil-veh.org>
To switch to the DIGEST mode, send e-mail to <mil-veh-digest@mil-veh.org>
To reach a human, contact <ack@mil-veh.org>
This archive was generated by hypermail 2.1.4 : Fri Oct 28 2005 - 23:22:19 PDT