Re: [MV] trailer brakes

From: Bigfoot Ghille (ghille@writeme.com)
Date: Wed Dec 24 2003 - 21:17:02 PST

My M105A2 only has one air hose, and only brakes when air is applied to it.  The gladhand I connect my trailer to only "makes" air when the brakes are applied.  The passenger-side connection on my truck is broken.  Does that side have constant air?

----- Original Message -----
From: ke6myk@sbcglobal.net
Date: Wed, 24 Dec 2003 18:19:31 -0800
To: "Military Vehicles Mailing List"
Subject: Re: [MV] trailer brakes


Rich Sherman wrote:
> At 02:42 PM 12/24/2003, Trish & Carla wrote:
> >Doesn't loss of air to the air brakes cause the brakes to be
> >applied?
>
> Only if full air brakes and they are the 'spring brake' type. That's where
> the air holds against the springs in order to release the brakes. That's
> the air release you hear when the parking brake is applied. A lot of the
> mil trailers are air over hydraulic where the a ir pressure applies the
> brakes, no air then no brakes.

I've seen two styles of air-over-hydraulic systems on M105-series
1.5-ton 2-wheel trailers. One style (older, I presume) has one air
line which is connected to the service connection. When the truck
brakes are applied, air pressure on this line actuates the master
cylinder on the trailer. I don't think there's any break-away system.

The other style (newer, I presume) has two air lines. The service line
acts as described above. The emergency line fills an air tank on the
trailer through a one-way valve. If pressure is lost on the service
line, a pressure-sensing valve uses the pressure stored in the
trailer's tank to actuate the trailer's master cylinder.

Unlike true air brake systems with spring brakes, the latter style
still has manually-applied mechanical parking brake levers. The
break-away system isn't suitable for parking a disconnected trailer ,
because eventually the pressure in the trailer's tank will bleed off,
and the hydraulic brakes will no longer be applied.

I would really prefer to have true air brakes with spring brakes on my
green trucks and trailers, but that's not how most of my vehicles were
designed. Sigh.

--
Mark J. Blair, NF6X
PGP 2.6.2 public key available from http://www.keyserver.net/
Web page: http://www.qsl.net/ke6myk/

===Mil-Veh is a member-supported mailing list===
To unsubscribe, send e-mail to:
To switch to the DIGEST mode, send e-mail to
To reach a human, contact
--

__________________________________________________________
Sign-up for Ads Free at Mail.com
http://www.mail.com/?sr=signup

This archive was generated by hypermail 2.1.4 : Sat May 07 2005 - 20:26:59 PDT